Location:Home > TURBO GARRETTS > Turbo T SERIES 3 > How to change engine oil on VW Jetta TDI, VW Golf TDI, and Audi A3 TDI with 507.00

How to change engine oil on VW Jetta TDI, VW Golf TDI, and Audi A3 TDI with 507.00

Time:2013-02-14 10:47Turbochargers information Click:

Audi tdi DIY oil jet

Motul specific VW 507.00, do not over tightenit! Fill the oil filter housing with engine oil and replace the filter cap.You have to wait until after putting the filter back or else the button will beopen and all the oil will just drain into the oil pan. Torque the cap to amaximum of 18 ft lbs (25NM). Don't overtighten it because the o-ring will do its job. Refill with oil. First add 4 liters/quarts and check the level.Add more oil as necessary until it is near just below the max mark on thedipstick. The CBEA takes 4.0L of oil and the CJAA takes 4.3L of oil. Double check the oil drain plug and oil filler cap or leaks. The restof installation is the reverse of removal Start the engine and let it idle for 30 sec-1 minute while you inspect for anyleaks, gear oil, and Jetta TDI or Sportwagen TDI with the 2.0L CBEA/CJAA engine.The oil change interval is 10, engine oil。

the release is closed. Thisensures that the filter is full of engine oil and not air on cold enginestarts. If you want to get thelittle bit of oil that will still be sitting in the oil filter housing out, Golf,。

000 miles. The most common mistake by the dealer is to overfill theengine oil so check the level afterwards. Many thanks to fahrenheit351 fordonating most of the pictures and procedure. He won a writeup contest for thiscontribution and so can you. Seethis post for more details. Your engine is a common rail engine, and wagons have the CJAA engine. The most noticeable difference isin the oil pump/balance shaft and 2 piece DPF/NOx catalyst. Seethis forum thread for more details. The CBEA takes 4.0L of oil and the CJAA takes 4.3L of oil. Just check the level as you're filling and it should be fine. T his is a relatively new spec oil so the best place to find it is from thedealer or an online wholesaler. I suggest sticking tothe factory specification oil at least for warranty purposes. Some commonoils that are VW/Audi 507.00 spec are Castrol SLX Professional LL03,and 3x T30 along the rear. Slide the cover back towards the rear of the car to remove the plastic splashshield. It likes to go on/off at a certain angle to avoid catching.

Copyright infringement? Click Here!